BU Alumni Web

Bostonia: The Alumni Magazine of Boston University

Fall 2011 Table of Contents

Natural Gas Leaks Fuel Global Warming, Not Homes

BU researcher maps gas leaks on city streets

| From Explorations | By Rich Barlow. Video by Nicolae Ciorogan
Watch this video on YouTube

In the video above, watch Nathan Phillips and his colleagues detecting natural gas leaks in Boston. Photo by Kalman Zabarsky

Nathan Phillips is a meter-reader for the 21st century. The College of Arts & Sciences associate professor of geography and environment recently piled into a Nissan Murano with collaborators Bob Ackley and Eric Crosson and rambled through the streets of greater Boston to hunt for natural gas leaks. With the help of a strange-looking vacuum device attached to the car just below the rear bumper, the three have found geysers of gas gushing invisibly from underground pipes corroded by age. The leaks, Phillips says, contribute to global warming, could create explosions in some extreme cases, have killed or damaged up to 10,000 trees in Massachusetts (a disputed matter under litigation), and shaft rate-paying gas customers who must pick up the tab for wasted gas.

The vacuum sniffs up molecules into a suitcase-sized machine in the hatch called a cavity ringdown analyzer, where a laser beam ricochets off mirrors and through the collected particles. The more natural gas collected, the more the laser diminishes. When the machine detects a leak, numerical values on a display screen indicate how much gas is spurting; if there are multiple leaks, the display “looks like a stock market index during a busy day,” says Phillips. The machine instantly spits out the leaks’ locations and shows them on Google Earth maps as shafts of green, punching skyward like a light show.

There are a lot of leaks. One utility, National Grid, counts 14,000 in its system, which serves half of the Bay State, while Ackley, president of Gas Safety USA, a Massachusetts leak-detection company, puts the figure for all leaks at up to 30,000. Utilities reported 13.5 million cubic feet of gas lost from leaks throughout Massachusetts in 2009, an amount that is surely an undercount, according to the federal government, which collects the data.

In May, Phillips and company found a leak in Newton that was spewing 400 cubic feet of gas per day. “The average household uses about 200 cubic feet per day,” says Crosson, whose California company, Picarro, makes the analyzer. “So that leak was equivalent to two households opening up their gas stoves and heater without igniting them.”

The perils and price of leaking gas are the subject of a paper that Phillips, Crosson, and Ackley presented at a spring conference sponsored by the National Oceanic and Atmospheric Administration. Their research suggests that 7 percent to 15 percent of manmade methane (the main component of natural gas) in the atmosphere comes from these urban emissions. And that’s a problem: methane is a greenhouse gas that according to the United Nations is 21 times more potent than carbon dioxide at trapping heat in the atmosphere.

Nathan Phillips (left) and Eric Crosson check a display screen indicating the extent of a natural gas leak. One utility, National Grid, counts 14,000 leaks in its system, which serves half of Massachusetts. Photo by Kalman Zabarsky

Then there’s the money. The eight billion cubic feet of gas vented in Massachusetts in 2005 (that’s leaks plus gas unaccounted for because of other factors) was worth $41 million, and that annual leak of gas and dollars continues. Gas customers pay a monthly maintenance charge already, in addition to being charged for the gas that leaks away, says Ackley, who for years worked to detect leaks for National Grid and other utilities. He estimates that leaks could add $40 a year to the average Bay State residential gas bill.

Leaking gas also kills or damages millions of dollars worth of urban trees—between $15 million and $25 million just in the commonwealth alone, says Ackley, who with Jan Schlichtmann (the lawyer hero of the book and film A Civil Action) runs the Massachusetts Public Shade Tree Trust, which seeks damages from utilities for affected municipalities.

Brookline is suing National Grid, which serves 1.2 million customers there and throughout Massachusetts, for damages to town trees allegedly caused by gas. Company spokesman David Graves says he can’t comment on pending litigation, but he does say that there is no scientific evidence supporting claims that underground gas leaks cause widespread damage to trees. “We work with communities on individual cases where they believe gas may have damaged a tree,” he says. “If we can prove gas is responsible, we replace the tree at our cost.”

Graves says his company takes the leaks issue very seriously and responds to every reported odor of gas. “We are in complete compliance with state and federal standards in leak management,” he says.

Phillips says utilities triage their repairs to remedy catastrophic leaks, such as the one that occurred near San Francisco last year, when a gas transmitting line exploded, killing four and torching dozens of homes. He found one leak in West Newton, Mass., with methane levels that would rate as potentially explosive.

By contrast, Phillips says, slower street-level leaks are bottom-tier concerns for repair, even though pedestrians occasionally can smell the gas.

Ackley tracked gas leaks for years before teaming with Phillips, whom he met by chance. Walking with his toddler son in their Newton neighborhood, Phillips spied Ackley in a yard wielding a strange handheld device. Curious, he asked Ackley what he was doing.

Picarro’s machine has revolutionized the labor of leak detection since Phillips and Ackley began using it last winter. “I can find the leaks with the old-school equipment we’ve been using in the gas industry for years,” says Ackley, “but this equipment is much more sensitive, and it has the ability to map out on GPS, right on a computer screen,” a leak’s location, “and also quantify the gas a little bit better.” The machine can sense leaks at any car speed, Crosson adds. “I’ve done it doing 65 miles an hour.”

So far, Crosson, Phillips, and Ackley have surveyed only a small percentage of Boston streets, and they plan to publish more comprehensive leak data from the city.

Download: Download this Article

Print: Print this Article


Email: Email this Article

The content of this field is not retained.

Enter multiple email addresses separated with commas.


On 23 April 2012 at 1:59 PM, Anonymous wrote:

“Gas customers pay a monthly maintenance charge already, in addition to being charged for the gas that leaks away.” Please do explain how customers are being charged for gas that has escaped before it has passed thru their gas meters.

On 21 November 2011 at 4:35 PM, BJ wrote:

The Chemistry show that biological systems operating are impacted by the by the synthetic methane and other compounds in the admixture of N,gas combined with toxic products in the environment.. Humans and animals exposed are at risk of biodysfunction,.the problem is that that compounds are constractants and or dehydrants which block or prevent biogeneration..

On 31 October 2011 at 11:20 AM, Ken Willliams (CAS'83) wrote:

And the gas industry portrays itself as the "clean" fuel? Imagine if oil heating trucks leaked to the extent that gas lines do and had the same track record of killing trees—there would be an uproar.

The AG should ban their ads portraying themselves as environmentally friendly—they are not. One recent study found that the gas industry, as a whole, impacted the environment worse than even coal. Clean my eye!

Post Your Comment

The content of this field is kept private and will not be shown publicly.

Which is lightest? elephant, cat, moon, tissue

Persons who post comments are solely responsible for the content of their messages. Bostonia reserves the right to delete or edit messages.